alternativeАльтернативная энергетика и экология (ISJAEE)Alternative Energy and Ecology (ISJAEE)1608-8298Международный издательский дом научной периодики "Спейс10.15518/isjaee.2024.03.168-176alternative-2398Research ArticleXV. ЭНЕРГОСБЕРЕЖЕНИЕ. 35. Энергосберегающие технологии, системы, материалы и приборыXV. ENERGY SAVING. 35. Energy-Saving Technologies, Systems, Materials, and InstrumentsРазработка системы управления для оптимального сопряжения энергосети с электролизерами и водородными топливными элементами для парирования провального периодаDevelopment of a control system for optimal interfacing of the power grid with electrolyzers and hydrogen fuel cells to parry the down periodКучакС. В.KuchakS. V.

Кучак Сергей Викторович - доцент кафедры электроники и электротехники, кандидат технических наук 

Новосибирск 

Sergey V. Kuchak - assistant professor of Electronics and Electrical Engineering Department, Candidate of Technical Sciences 

 Novosibirsk 

kuchak.2012@corp.nstu.ruШтейнД. А.ShteinD. A.

Штейн Дмитрий Александрович -  заместитель директора Института силовой электроники

 Новосибирск 

 Dmitry A. Shtein - vice-director of Institute of Power Electronic 

 Novosibirsk 

Новосибирский государственный технический университетРоссияNovosibirsk State Technical UniversityRussian Federation20240706202403168176Copyright © Международный издательский дом научной периодики "Спейс, 20232023Международный издательский дом научной периодики "СпейсМеждународный издательский дом научной периодики "Спейсhttps://www.isjaee.com/jour/about/submissions#copyrightNoticehttps://www.isjaee.com/jour/article/view/2398

В работе представлены результаты анализа параметров последовательного резонансного преобразователя с фиксирующими диодами CSRC. Условия работы преобразователя подразумевают широкий диапазон изменения входного напряжения и мощности нагрузки. Предложена система управления на основе частотно-импульсного регулирования. Задание частоты производится на основе входного напряжения, выходного тока и параметров преобразователя. Применимость способа управления проверена моделированием. Рассмотрены режимы пуска на максимальную мощность при минимальном входном напряжении. Полученные результаты соответствуют техническому заданию.

The paper presents the results of an analysis of the parameters of a series resonant converter with clamping diodes CSRC. The operating conditions of the converter imply a wide range of changes in input voltage and load power. A control system based on pulse-frequency regulation is proposed. The frequency is set based on the input voltage, output current and converter parameters. The applicability of the control method has been verified by simulation. Starting modes at maximum power and minimum input voltage are considered. The results obtained correspond to the technical specifications.

водородводородные топливные элементыводородный электролизеррезонансный преобразовательширокий диапазон входного напряжениясистема управленияимитационная модельрезкие изменения нагрузкиhydrogenhydrogen fuel cellshydrogen electrolyzerresonant converterwide input voltage rangecontrol systemsimulation modelsudden load changesReferencesD. Concha, H. Renaudineau, M. S. Hernández, A. M. Llor, S. Kouro. «Evaluation of DCX converters for off-grid photovoltaic-based green hydrogen production». International Journal of Hydrogen Energy, Volume 46, Issue 38, 2021, pp. 19861-19870.D. Concha, H. Renaudineau, M. S. Hernández, A. M. Llor, S. Kouro. «Evaluation of DCX converters for off-grid photovoltaic-based green hydrogen production». International Journal of Hydrogen Energy, Volume 46, Issue 38, 2021, pp. 19861-19870.G. Spiazzi. «Analysis and design of the softswitched clamped-resonant interleaved boost converter» in CPSS Transactions on Power Electronics and Applications. – Vol. 4, no. 4, pp. 276-287.G. Spiazzi. «Analysis and design of the softswitched clamped-resonant interleaved boost converter» in CPSS Transactions on Power Electronics and Applications. – Vol. 4, no. 4, pp. 276-287.I. Voronin, P. Voronin and O. Osipov. «The Efficiency Analysis of Resonant Circuits in High-Power Converters of Electrical Energy with Soft Switching Mode». 2021 28th International Workshop on Electric Drives: Improving Reliability of Electric Drives (IWED), Moscow, Russia, 2021, pp. 1-6.I. Voronin, P. Voronin and O. Osipov. «The Efficiency Analysis of Resonant Circuits in High-Power Converters of Electrical Energy with Soft Switching Mode». 2021 28th International Workshop on Electric Drives: Improving Reliability of Electric Drives (IWED), Moscow, Russia, 2021, pp. 1-6.Q. Duan, G. Sha, C. Zhao and C. Ma. «Soft-Switching Analysis of Isolated Bidirectional LC Series Resonant DC-DC Converter with Phase-Shift Control». 2018 2nd IEEE Conference on Energy Internet and Energy System Integration (EI2), Beijing, China, 2018, pp. 1-9.Q. Duan, G. Sha, C. Zhao and C. Ma. «Soft-Switching Analysis of Isolated Bidirectional LC Series Resonant DC-DC Converter with Phase-Shift Control». 2018 2nd IEEE Conference on Energy Internet and Energy System Integration (EI2), Beijing, China, 2018, pp. 1-9.E. Chu, X. Hou and H. Zhang. «A Novel Soft Switching Converter with Active Auxiliary Resonant Commutation» in Chinese Journal of Electronics, vol. 21, no. 4, pp. 751-755, October 2012.E. Chu, X. Hou and H. Zhang. «A Novel Soft Switching Converter with Active Auxiliary Resonant Commutation» in Chinese Journal of Electronics, vol. 21, no. 4, pp. 751-755, October 2012.Y. Dong-Ying, K. Shih-Hao, S. Yong-Long, C. Huang-Jen, L. Kuo-Chi and Y. Ta-Yung. «An Improved 48-to-12V Series-Parallel Resonant Switched-Capacitor Converter for Data Center Applications» 2021 IEEE International Future Energy Electronics Conference (IFEEC), Taipei, Taiwan, 2021, pp. 1-6.Y. Dong-Ying, K. Shih-Hao, S. Yong-Long, C. Huang-Jen, L. Kuo-Chi and Y. Ta-Yung. «An Improved 48-to-12V Series-Parallel Resonant Switched-Capacitor Converter for Data Center Applications» 2021 IEEE International Future Energy Electronics Conference (IFEEC), Taipei, Taiwan, 2021, pp. 1-6.X. Li, H. Hu, L. Guo and R. Zou. «A Matrix-Converter-Based Single-Stage AC-DC Converter with a LLC Resonant Tank to Realize Soft Switching». 2020 IEEE 9th International Power Electronics and Motion Control Conference (IPEMC2020-ECCE Asia), Nanjing, China, 2020, pp. 1555-1559.X. Li, H. Hu, L. Guo and R. Zou. «A Matrix-Converter-Based Single-Stage AC-DC Converter with a LLC Resonant Tank to Realize Soft Switching». 2020 IEEE 9th International Power Electronics and Motion Control Conference (IPEMC2020-ECCE Asia), Nanjing, China, 2020, pp. 1555-1559.S. Khan, A. Chub and D. Vinnikov. «An Overview of Wide-Voltage Range Isolated DC-DC Converters», 2023 IEEE 64th International Scientific Conference on Power and Electrical Engineering of Riga Technical University (RTUCON), Riga, Latvia, 2023, pp. 1-6.S. Khan, A. Chub and D. Vinnikov. «An Overview of Wide-Voltage Range Isolated DC-DC Converters», 2023 IEEE 64th International Scientific Conference on Power and Electrical Engineering of Riga Technical University (RTUCON), Riga, Latvia, 2023, pp. 1-6.S. Pourjafar, P. Mohseni, O. Matiushkin, O. Husev and D. Vinnikov. «Novel Isolated High Step-up DC-DC Converter with Wide Input Voltage Regulation Range». 2023 IEEE 64th International Scientific Conference on Power and Electrical Engineering of Riga Technical University (RTUCON), Riga, Latvia, 2023, pp. 1-6.S. Pourjafar, P. Mohseni, O. Matiushkin, O. Husev and D. Vinnikov. «Novel Isolated High Step-up DC-DC Converter with Wide Input Voltage Regulation Range». 2023 IEEE 64th International Scientific Conference on Power and Electrical Engineering of Riga Technical University (RTUCON), Riga, Latvia, 2023, pp. 1-6.K. V. Anandkrishnan, S. S. Kumar, A. T. T and J. P. «High Gain Converter Based Fuel Cell-Battery System for Electric Vehicles and Residential Applications». 2022 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Jaipur, India, 2022, pp. 1-6K. V. Anandkrishnan, S. S. Kumar, A. T. T and J. P. «High Gain Converter Based Fuel Cell-Battery System for Electric Vehicles and Residential Applications». 2022 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Jaipur, India, 2022, pp. 1-6A. Rajabi, M. G. Marangalu, A. Rajaei, F. M. Shahir, M. R. Islam and R. Shah. «Implementation and Efficiency Calculation of Fuel-Cell Vehicles Using a Bidirectional DC/DC Converter with ZVS». 2022 IEEE 1st Industrial Electronics Society Annual On-Line Conference (ONCON), kharagpur, India, 2022, pp. 1-5A. Rajabi, M. G. Marangalu, A. Rajaei, F. M. Shahir, M. R. Islam and R. Shah. «Implementation and Efficiency Calculation of Fuel-Cell Vehicles Using a Bidirectional DC/DC Converter with ZVS». 2022 IEEE 1st Industrial Electronics Society Annual On-Line Conference (ONCON), kharagpur, India, 2022, pp. 1-5S. Chaudhary and Y. K. Chauhan. «Studies and performance investigations on fuel cells». 2014 International Conference on Advances in Engineering & Technology Research (ICAETR – 2014), Unnao, India, 2014, pp. 1-6.S. Chaudhary and Y. K. Chauhan. «Studies and performance investigations on fuel cells». 2014 International Conference on Advances in Engineering & Technology Research (ICAETR – 2014), Unnao, India, 2014, pp. 1-6.Xiangwan Liu, Yang Yang, Lingxian Zhang, Shenpei Zhou, Lamei Xu, Changjun Xie, Bo Zhao, Leiqi Zhang. «Uncertainty assessment of a semi-empirical output voltage model for proton exchange membrane fuel cells». International Journal of Hydrogen Energy. – Vol.48, Issue 29, 2023, pp. 11071-11085.Xiangwan Liu, Yang Yang, Lingxian Zhang, Shenpei Zhou, Lamei Xu, Changjun Xie, Bo Zhao, Leiqi Zhang. «Uncertainty assessment of a semi-empirical output voltage model for proton exchange membrane fuel cells». International Journal of Hydrogen Energy. – Vol.48, Issue 29, 2023, pp. 11071-11085.H. Liu, L. Xu, Z. Hu, J. Li, H. Jiang and M. Ouyang. «Experimental Study and Performance Analysis on High Power Fuel Cell System». IECON 2020 The 46th Annual Conference of the IEEE Industrial Electronics Society, Singapore, 2020, pp. 2031-2035H. Liu, L. Xu, Z. Hu, J. Li, H. Jiang and M. Ouyang. «Experimental Study and Performance Analysis on High Power Fuel Cell System». IECON 2020 The 46th Annual Conference of the IEEE Industrial Electronics Society, Singapore, 2020, pp. 2031-2035S. V. Kuchak, A. N. Voroshilov and E. A. Chudinov. «Discharge characteristics of lithium-ion accumulators under different currents». 2017 18th International Conference of Young Specialists on Micro/Nanotechnologies and Electron Devices (EDM), Erlagol, Russia, 2017, pp. 435-438.S. V. Kuchak, A. N. Voroshilov and E. A. Chudinov. «Discharge characteristics of lithium-ion accumulators under different currents». 2017 18th International Conference of Young Specialists on Micro/Nanotechnologies and Electron Devices (EDM), Erlagol, Russia, 2017, pp. 435-438.S. Ananda, N. Lakshminarasamma, V. Radhakrishna, M. S. Srinivasan, P. Satyanarayana and M. Sankaran. «Generic Lithium ion battery model for energy balance estimation in spacecraft». 2018 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Chennai, India, 2018, pp. 1-5.S. Ananda, N. Lakshminarasamma, V. Radhakrishna, M. S. Srinivasan, P. Satyanarayana and M. Sankaran. «Generic Lithium ion battery model for energy balance estimation in spacecraft». 2018 IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Chennai, India, 2018, pp. 1-5.W. Roshen. «Load Independent, Enhanced Power Extraction from a Solar Cell: Modifying the Output Characteristics of a Solar Cell Externally». 2023 Middle East and North Africa Solar Conference (MENA-SC), Dubai, United Arab Emirates, 2023, pp. 1-3W. Roshen. «Load Independent, Enhanced Power Extraction from a Solar Cell: Modifying the Output Characteristics of a Solar Cell Externally». 2023 Middle East and North Africa Solar Conference (MENA-SC), Dubai, United Arab Emirates, 2023, pp. 1-3T. Nakamura, L. Zhu, M. Yoshita, M. Imaizumi, H. Akiyama and Y. Okada. «Quantitative loss analysis of voltage output characteristics on multi-junction solar cells». 2018 IEEE 7th World Conference on Photovoltaic Energy Conversion (WCPEC) (A Joint Conference of 45th IEEE PVSC, 28th PVSEC & 34th EU PVSEC), Waikoloa, HI, USA, 2018, pp. 0921-0926T. Nakamura, L. Zhu, M. Yoshita, M. Imaizumi, H. Akiyama and Y. Okada. «Quantitative loss analysis of voltage output characteristics on multi-junction solar cells». 2018 IEEE 7th World Conference on Photovoltaic Energy Conversion (WCPEC) (A Joint Conference of 45th IEEE PVSC, 28th PVSEC & 34th EU PVSEC), Waikoloa, HI, USA, 2018, pp. 0921-0926M. S. Khesbak and A. A. Ibraheem. «Design and Simulation of a Solar Power System Oriented for Mobile Base Station Sites». 2021 IEEE International Conference in Power Engineering Application (ICPEA), Malaysia, 2021, pp. 18-23.M. S. Khesbak and A. A. Ibraheem. «Design and Simulation of a Solar Power System Oriented for Mobile Base Station Sites». 2021 IEEE International Conference in Power Engineering Application (ICPEA), Malaysia, 2021, pp. 18-23.X. Sun, X. Li, Y. Shen, B. Wang, and X. Guo. «Dual-Bridge LLC Resonant Converter with Fixed-Frequency PWM Control for Wide Input Applications». IEEE Trans. Power Electron. – Vol. 32, no. 1, pp. 69–80, 2017.X. Sun, X. Li, Y. Shen, B. Wang, and X. Guo. «Dual-Bridge LLC Resonant Converter with Fixed-Frequency PWM Control for Wide Input Applications». IEEE Trans. Power Electron. – Vol. 32, no. 1, pp. 69–80, 2017.W. Sun, Y. Xing, H. Wu, and J. Ding. «Modified High-Efficiency LLC Converters with Two Split Resonant Branches for Wide Input-Voltage Range Applications». IEEE Trans. Power Electron. – Vol. 33, no. 9, pp. 7867-7879, 2018.W. Sun, Y. Xing, H. Wu, and J. Ding. «Modified High-Efficiency LLC Converters with Two Split Resonant Branches for Wide Input-Voltage Range Applications». IEEE Trans. Power Electron. – Vol. 33, no. 9, pp. 7867-7879, 2018.Y. Chen, H. Wang, Y. F. Liu, J. Afsharian, and Z. A. Yang. «Efficiency-wise optimal design methodology of LCLC converter for wide input voltage range applications». ECCE 2016 – IEEE Energy Convers. Congr. Expo. Proc., pp. 1-8, 2016.Y. Chen, H. Wang, Y. F. Liu, J. Afsharian, and Z. A. Yang. «Efficiency-wise optimal design methodology of LCLC converter for wide input voltage range applications». ECCE 2016 – IEEE Energy Convers. Congr. Expo. Proc., pp. 1-8, 2016.Z. Liang, R. Guo, G. Wang, and A. Huang. «A new wide input range high efficiency photovoltaic inverter». 2010 IEEE Energy Convers. Congr. Expo. ECCE 2010. – Proc., pp. 2937-2943, 2010.Z. Liang, R. Guo, G. Wang, and A. Huang. «A new wide input range high efficiency photovoltaic inverter». 2010 IEEE Energy Convers. Congr. Expo. ECCE 2010. – Proc., pp. 2937-2943, 2010.B. R. Lin, J. J. Dai, and Y. K. Du. «Analysis of a new resonant converter with auxiliary windings to extend input voltage range». Proc. 2nd Int. Conf. Intell. Green Build. Smart Grid, IGBSG 2016, pp. 1-6, 2016.B. R. Lin, J. J. Dai, and Y. K. Du. «Analysis of a new resonant converter with auxiliary windings to extend input voltage range». Proc. 2nd Int. Conf. Intell. Green Build. Smart Grid, IGBSG 2016, pp. 1-6, 2016.S. M. S. I. Shakib and S. Mekhilef. «A Frequency Adaptive Phase Shift Modulation Control Based LLC Series Resonant Converter for Wide Input Voltage Applications». IEEE Trans. Power Electron. – Vol. 32, no. 11, pp. 8360-8370, 2017.S. M. S. I. Shakib and S. Mekhilef. «A Frequency Adaptive Phase Shift Modulation Control Based LLC Series Resonant Converter for Wide Input Voltage Applications». IEEE Trans. Power Electron. – Vol. 32, no. 11, pp. 8360-8370, 2017.W. Sun, H. Wu, H. Hu, and Y. Xing. «Modified LLC resonant converter with secondary paralleled bidirectional switch for applications with hold-up time requirement». IET Power Electron. – Vol. 10, no. 3, pp. 398-404, 2017.W. Sun, H. Wu, H. Hu, and Y. Xing. «Modified LLC resonant converter with secondary paralleled bidirectional switch for applications with hold-up time requirement». IET Power Electron. – Vol. 10, no. 3, pp. 398-404, 2017.K. H. Yoon, Y. J. Noh, S. Phum, S. Meas, S. H. Jang, and E. S. Kim. «LLC resonant converter with wide input voltage and load range at fixed switching frequency». – Conf. Proc. – IEEE Appl. Power Electron. Conf. Expo. – APEC, pp. 1338-1342, 2012.K. H. Yoon, Y. J. Noh, S. Phum, S. Meas, S. H. Jang, and E. S. Kim. «LLC resonant converter with wide input voltage and load range at fixed switching frequency». – Conf. Proc. – IEEE Appl. Power Electron. Conf. Expo. – APEC, pp. 1338-1342, 2012.D. Temkin, U. Carlsson, G. Dakermanji. «Development of a multiple output resonant converter for space applications». APEC’88 Third Annual IEEE Applied Power Electronics Conference and Exposition, 2/New Orleans, LA, USA, 1988, pp. 167-181.D. Temkin, U. Carlsson, G. Dakermanji. «Development of a multiple output resonant converter for space applications». APEC’88 Third Annual IEEE Applied Power Electronics Conference and Exposition, 2/New Orleans, LA, USA, 1988, pp. 167-181.R. Ramabhadran, X. She, Y. Levy, J. Glaser, R. Raju and R. Datta. «Universal AC input high density power adapter design with a Clamped Series Resonant Converter». 2015 IEEE Energy Conversion Congress and Exposition (ECCE), Montreal, QC, Canada, 2015, pp. 5857-5864.R. Ramabhadran, X. She, Y. Levy, J. Glaser, R. Raju and R. Datta. «Universal AC input high density power adapter design with a Clamped Series Resonant Converter». 2015 IEEE Energy Conversion Congress and Exposition (ECCE), Montreal, QC, Canada, 2015, pp. 5857-5864.M. A. Khoroshev, D. V. Makarov, A. G. Volkov and I. V. Zaev. «Analysis of dynamic properties of resonant converter in a power supply system of autonomous object». 2017 18th International Conference of Young Specialists on Micro/Nanotechnologies and Electron Devices (EDM), Erlagol, Russia, 2017, pp. 487-490.M. A. Khoroshev, D. V. Makarov, A. G. Volkov and I. V. Zaev. «Analysis of dynamic properties of resonant converter in a power supply system of autonomous object». 2017 18th International Conference of Young Specialists on Micro/Nanotechnologies and Electron Devices (EDM), Erlagol, Russia, 2017, pp. 487-490.

The authors declare that there are no conflicts of interest present.